广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
10631
当梅雨季或台风天鸽季来二次,有很有也许遭到洪涝洪涝、雷暴等生态洪涝的决定,因汽油打着机并网同步变频电动机马达组机房设备通常现状下是在地下停车场室还有1楼轻易被水淹,只要并网同步变频电动机马达组管理安全防护不当还有另外的诱因水有很有也许从烟管开始打着机缸体。当汽油打着机并网同步变频电动机马达组取水时,诸如启动请再次断电,并展开一定要的保障措施,掉线外电源线及蓄畜电池接驳线,直接检验每一个身体部位的取水现状。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、查看res排气线路(排烟口管评均处或消音器)的排水性杆件能否存水出排。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、检测空气质量空气过滤芯护壳是不是有内的积水,过滤芯是不是被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、观察带发无刷电机壳子下方是不是有积液。Check whether there is water accumulated at the bottom of the generator casing.


4、查检热量散发器、电扇、轴承等转动安全装置有无赌塞。Check radiator, fan, coupling for blockage.


5、外链需不需要有机的油、汽柴油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸掉顶杆室盖,了解可否有浸水。体检并网发三相异步电机绕阻绝缘性/破坏的情况。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、判断管理路线和导出电路板的电绝缘。判断管理打开面板控制模块、各仪器仪表、告警部件、起动打开。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


目光:相对不要让水倾入起因素的引燃室!Note: Never let water enter the combustion chamber of the engine!


漏电正确处理方式方法静音带发直流无刷电发动机入水后的加工妙招:Treatment  after water enter the generator:


当确定汽油车来发同步交流接触器柜热车机的燃燒室也没有存水,绝缘电阻达到规范时,可重新起动汽油车来发同步交流接触器柜。在重新起动时要需要注意这疑问:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在重启行进行大部分进行检查,有排污然油箱结水。机械设备日益上电,关注有没有无效。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、累计起动打着机的时刻不允许少于5秒钟。若打着机不会自燃,则检修然油管线及电气设备回路开关,二两半小时后再度起动。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、全面检测发起机心声有没有有无效,有没有有臭味。全面检测机电仪表盘的彰显、液晶电视机彰显屏有没有断屏或彰显不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、增进了解汽车发动机机油气压和水温差,如何液压或温差有误合技术工艺规程,应退出发起机。断电后,检杳单次汽车发动机机油立体。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当答案起行为也许 浸水、带发电量机接地不相适合需求时,不要强行维修培训,应合作的英文带发电量飞机机组厂的技術技術师的有助于。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


特大暴雨/潮湿的室内环境,重油发电站设备利用小心重点难点Key points for unit operation in rainstorm / humid environment


1、保存环保符合要求1. Placement environment requirements(1)室外置放选择的发电机组,需做到遮阳政策,安装遮阳棚、静音模式箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)机柜金属外壳须有准确的保护好接地装置线装置,对都要有碱性点马上接地装置线装置的风能发变频电动机,则就必须由的专业工作人员完成碱性接地装置线装置;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)闪电高发各地适用丝机,请安装防雷提升装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请不会将飞机机组置放于位置较低,房基不牢(土壤水平面)比较容易淹水的地区;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)摆放在在地下商场隧道室使用的的仪器,需制作好地下商场隧道室泄水、防水事业。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
分享稿件
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 微混合器,管式反应器,加氢站换热器,加氢机换热器,微通道反应器,气化器,高效换热器,印刷电路板式换热器,热水换热器,水冷换热器,油冷换热器,污水换热器,热水机换热器" 别告诉妈妈biegaosumama